Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method

Samet Uslu (Mechanical Engineering Department, Faculty of Engineering, Karabuk University, Karabuk, 78050, Turkey)
International Journal of Automotive Science and Technology
2 0
Yıl: 2020 Cilt: 4 Sayı: 3 Sayfa Aralığı: 171 - 179 Metin Dili: İngilizce DOI: 10.30939/ijastech..770068 İndeks Tarihi: 17-09-2020

Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method

Öz:
In present study, it was targeted to optimize multiple impacts of palm oil ratio,diethyl ether (DEE) percentage and engine load on the performance and emissionsof a single cylinder diesel engine. The experiments were designed based on theTaguchi L27 orthogonal array which accepts palm oil percentage, DEE ratio andload as variables, brake thermal efficiency (BTE), brake specific fuel consumption (BSFC), nitrogen oxide (NOx) emission and smoke emission as responses.The impacts of engine running factors on responses were defined by analysis ofvariance (ANOVA). S / N ratio plots were created for each answer to show optimum factor levels. The results showed that the most influential parameters in general on all engine outputs are the load and DEE ratio. Additionally, consideringthe findings, the best working variables of the engine were determined as 5% DEEpercentage, 6% palm oil percentage, and 850-Watt load. The best BTE, BSFC,NOx and smoke emission obtained according to optimum working parameterswere found as 30.73%, 824.59 g/kWh, 292.20 ppm and 68.91%, respectively.Mean errors between experimental and optimized results were found as 0.46%,1.75%, 3.72% and 0.16% for BTE, BSFC, NOx and smoke emission, respectively.These results showed that the Taguchi design method can be used as an effectivetool to determine the impact rates of engine operating parameters and to optimizeoperating parameters, engine performance and emissions based on the determinedimpact rates.
Anahtar Kelime:

Belge Türü: Makale Makale Türü: Araştırma Makalesi Erişim Türü: Erişime Açık
  • [1] Santhosh, K., Kumar, G.N., Radheshyam and Sanjay, P.V., (2020). Experimental analysis of performance and emission characteristics of CRDI diesel engine fueled with 1-pentanol/diesel blends with EGR technique, Fuel, 267.
  • [2] Simsek, S., (2020). Effects of biodiesel obtained from Canola, sefflower oils and waste oils on the engine performance and exhaust emissions, Fuel, 265, 117026.
  • [3] Vigneswaran, R., Annamalai, K., Dhinesh, B. and Krishnamoorthy, R., (2018). Experimental investigation of unmodified diesel engine performance, combustion, and emission with multipurpose additive along with water-in-diesel emulsion fuel, Energy Conversion and Management, 172, 370–380.
  • [4] Pan, H., Li, H., Zhang, H., Wang, A., Jin, D. and Yang, S., (2018). Effective production of biodiesel from non-edible oil using facile synthesis of imidazolium salts-based BrønstedLewis solid acid and co-solvent, Energy Conversion and Management, 166, 534–544.
  • [5] Simsek, S. and Uslu, S., (2020). Determination of a diesel engine operating parameters powered with canola, safflower and waste vegetable oil-based biodiesel combination using response surface methodology (RSM), Fuel, 270, 117496.
  • [6] Uslu, S., (2020). Optimization of diesel engine operating parameters fueled with palm oil-diesel blend: Comparative evaluation between response surface methodology (RSM) and artificial neural network (ANN), Fuel, 276, 117990.
  • [7] Rajak, U., Nashine, P. and Verma, T.N., (2020). Effect of spirulina microalgae biodiesel enriched with diesel fuel on performance and emission characteristics of CI engine, Fuel, 268.
  • [8] Nanthagopal, K., Ashok, B., Garnepudi, R.S., Tarun, K.R. and Dhinesh, B., (2019). Investigation on diethyl ether as an additive with Calophyllum Inophyllum biodiesel for CI engine application, Energy Conversion and Management, 179, 104–113.
  • [9] Uslu, S. and Celik, M. B., (2018). Prediction of engine emissions and performance with artificial neural networks in a single cylinder diesel engine using diethyl ether, Engineering Science and Technology, An International Journal, 21 (6).
  • [10]Yesilyurt, M.K., Yilbasi, Z. and Aydin, M., (2020). The performance, emissions, and combustion characteristics of an unmodified diesel engine running on the ternary blends of pentanol/safflower oil biodiesel/diesel fuel, J Therm Anal Calorim.
  • [11]Arya, S., Sharma, A., Rawat, M. and Agrawal, A., (2020). Tyre pyrolysis oil as an alternative fuel: A review, Materials Today: Proceedings.
  • [12]Aydın, M., Uslu, S. and Çelik, M. B., (2020). Performance and emission prediction of a compression ignition engine fueled with biodiesel-diesel blends: A combined application of ANN and RSM based optimization, Fuel, 269.
  • [13]Yesilyurt, M.K. and Arslan, M., (2019). Analysis of the fuel injection pressure effects on energy and exergy efficiencies of a diesel engine operating with biodiesel, Biofuels, 10 (5), 643–655.
  • [14]Simsek, S. and Uslu, S., (2020). Experimental study of the performance and emissions characteristics of fusel oil/gasoline blends in spark ignited engine using response surface methodology, Fuel, 277, 118182.
  • [15]Bari, S. and Hossain, S. N., (2019). Performance and emission analysis of a diesel engine running on palm oil diesel (POD), Energy Procedia, 160, 92–99.
  • [16]Ge, J. C., Kim, H. Y., Yoon, S. K. and Choi, N. J., (2020). Optimization of palm oil biodiesel blends and engine operating parameters to improve performance and PM morphology in a common rail direct injection diesel engine, Fuel, 260, 116326.
  • [17]Şanlı, B. G., Uludamar, E. and Özcanlı, M., (2019). Evaluation of energetic-exergetic and sustainability parameters of biodiesel fuels produced from palm oil and opium poppy oil as alternative fuels in diesel engines, Fuel, 258.
  • [18]Gad, M.S., El-Araby, R., Abed, K.A., El-Ibiari, N.N., El Morsi, A.K. and Ed. G. I., (2018). Performance and emissions characteristics of C.I. engine fueled with palm oil/palm oil methyl ester blended with diesel fuel, Egyptian Journal Of Petroleum, 27 (2), 215–219.
  • [19]Allami, H. A., Tabasizadeh, M., Rohani, A., Farzad, A. and Nayebzadeh, H., (2019), Precise evaluation the effect of microwave irradiation on the properties of palm kernel oil biodiesel used in a diesel engine, Journal Of Cleaner Production, 241, 1177777.
  • [20]Heidari-Maleni, A., Gundoshmian, T. M., Jahanbakhshi, A. and Ghobadian, B., (2020). Performance improvement and exhaust emissions reduction in diesel engine through the use of graphene quantum dot (GQD) nanoparticles and ethanol-biodiesel blends, Fuel, 267, 117116.
  • [21]Uslu, S. and Aydın, M., (2020). Effect of operating parameters on performance and emissions of a diesel engine fueled with ternary blends of palm oil biodiesel/diethyl ether/diesel by Taguchi method, Fuel, 275, 117978.
  • [22]Di, Y., Ni, Z., Yage, D. I., Zuohua, H., and Zhiyuan, Z., (2010). Flame instability analysis of diethyl ether-air premixed mixtures at elevated pressures Flame instability analysis of diethyl ether-air premixed mixtures at elevated pressures.
  • [23]Rakopoulos, D. C., Rakopoulos, C. D., Giakoumis, E. G., Papagiannakis, R. G., and Kyritsis, D. C., (2014). Influence of properties of various common biofuels on the combustion and emission characteristics of high-speed DI (direct injection) diesel engine: Vegetable oil, biodiesel, ethanol, n -butanol, diethyl ether, Energy, 73, 354–366.
  • [24]Lee, S. and Kim, T. Y., (2017). Performance and emission characteristics of a DI diesel engine operated with diesel/DEE blended fuel, Applied Thermal Engineering, 121, 454–461.
  • [25]Nishanth, S., Gunasekar, N., Nanthakumar, S., Prakash, R. and Kumar, T. S., (2020). Experimental investigation on performance and emission characteristics of VCR engine working with biodiesel and Diethyl Ether, Materials Today: Proceedings.
  • [26]Yesilyurt, M. K. and A. M., (2020). Experimental investigation on the performance, combustion and exhaust emission characteristics of a compression-ignition engine fueled with cottonseed oil biodiesel/diethyl ether/diesel fuel blends, Energy Conversion and Management, 205.
  • [27]Uslu, S. and Celik, M. B., (2018). Experimental investigation of the effects of diethyl ether- diesel fuel blends on engine parameters in a low power diesel engine, International Journal of Engineering Sciences & Research Technology, 7 (5), 1–13.
  • [28]Loganathan, M., Madhavan, V. M., Balasubramanian, K. A., Thanigaivelan, V., Vikneswaran, M. and Anbarasu, A., (2020). Investigation on the effect of diethyl ether with hydrogen-enriched cashew nutshell (CNS) biodiesel in direct injection (DI) diesel engine, Fuel, 277, 118165.
  • [29]Prabhahar, M., Prakash, S., George, I., Swaroop and Amith, K.K., (2020). Optimization of performance and emission characteristics of bio diesel fuelled VCR engine using Taguchi approach, Materials Today: Proceedings.
  • [30]Sharma, A., Ansari, N. A., Singh, Y., Mustefa, I. and Vivekanandhan, C., (2018). Optimization of engine parameters using Polanga biodiesel and diesel blends by using Taguchi method, Materials Today: Proceedings, 5 (14), 28221–28228.
  • [31]Manigandan, S., Atabani, A.E., Ponnusamy, V.K., Pugazhendhi, A., Gunasekar, P. and Prakash, S., (2020). Effect of hydrogen and multiwall carbon nanotubes blends on combustion performance and emission of diesel engine using Taguchi approach, Fuel, 276, 118120.
  • [32]Özel, S., Vural, E. and Binici, M., (2020). Optimization of the effect of thermal barrier coating (TBC) on diesel engine performance by Taguchi method, Fuel, 263.
  • [33]Uslu, S. and Aydın, M., (2020). Effect of operating parameters on performance and emissions of a diesel engine fueled with ternary blends of palm oil biodiesel/diethyl ether/diesel by Taguchi method, Fuel, 275, 117978.
  • [34]Kumar, R.S., Sureshkumar, K. and Velraj, R., (2015). Optimization of biodiesel production from Manilkara zapota (L.) seed oil using Taguchi method, Fuel, 140, 90–96.
  • [35]Bose, P. K., Deb, M., Banerjee, R. and Majumder, A., (2013). Multi objective optimization of performance parameters of a single cylinder diesel engine running with hydrogen using a Taguchi-fuzzy based approach, Energy, 63, 375–386.
  • [36]Raghuvaran, S., Ashok, B., Veluchamy, B. and Ganesh, N., (2020). Evaluation of performance and exhaust emission of C.I diesel engine fuel with palm oil biodiesel using an artificial neural network, Materials Today: Proceedings, In Press.
  • [37]Shen, X., Shi, J., Cao, X., Zhang, X., Zhang, W., Wu, H. and Yao, Z., (2018). Real-world exhaust emissions and fuel consumption for diesel vehicles fueled by waste cooking oil biodiesel blends, Atmospheric Environment, 191, 249–257.
  • [38]Aydin, S., (2020). Comprehensive analysis of combustion, performance and emissions of power generator diesel engine fueled with different source of biodiesel blends, Energy, 205, 118074.
APA Uslu S (2020). Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. , 171 - 179. 10.30939/ijastech..770068
Chicago Uslu Samet Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. (2020): 171 - 179. 10.30939/ijastech..770068
MLA Uslu Samet Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. , 2020, ss.171 - 179. 10.30939/ijastech..770068
AMA Uslu S Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. . 2020; 171 - 179. 10.30939/ijastech..770068
Vancouver Uslu S Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. . 2020; 171 - 179. 10.30939/ijastech..770068
IEEE Uslu S "Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method." , ss.171 - 179, 2020. 10.30939/ijastech..770068
ISNAD Uslu, Samet. "Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method". (2020), 171-179. https://doi.org/10.30939/ijastech..770068
APA Uslu S (2020). Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. International Journal of Automotive Science and Technology, 4(3), 171 - 179. 10.30939/ijastech..770068
Chicago Uslu Samet Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. International Journal of Automotive Science and Technology 4, no.3 (2020): 171 - 179. 10.30939/ijastech..770068
MLA Uslu Samet Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. International Journal of Automotive Science and Technology, vol.4, no.3, 2020, ss.171 - 179. 10.30939/ijastech..770068
AMA Uslu S Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. International Journal of Automotive Science and Technology. 2020; 4(3): 171 - 179. 10.30939/ijastech..770068
Vancouver Uslu S Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method. International Journal of Automotive Science and Technology. 2020; 4(3): 171 - 179. 10.30939/ijastech..770068
IEEE Uslu S "Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method." International Journal of Automotive Science and Technology, 4, ss.171 - 179, 2020. 10.30939/ijastech..770068
ISNAD Uslu, Samet. "Multi-Objective Optimization of Biodiesel and Diethyl Ether Doped Diesel Engine by Taguchi Method". International Journal of Automotive Science and Technology 4/3 (2020), 171-179. https://doi.org/10.30939/ijastech..770068
Sayfa Oluşturulma Tarihi
17-04-2024 15:39

İLETİŞİM

TÜBİTAK ULAKBİM TR Dizin

Yüzüncüyıl, İşçi Blokları Mahallesi

Muhsin Yazıcıoğlu Caddesi No:51/C

06530 Çankaya / ANKARA +90 (312) 298 92 00

trdizin@tubitak.gov.tr

TÜBİTAK ULAKBİM Ulusal Akademik Ağ ve Bilgi Merkezi Cahit Arf Bilgi Merkezi © Tüm Hakları Saklıdır. Gizlilik Politikası Kullanım Şartları